Experiments on the Spoilage of Tomato Ketchup

John George Brown, Sleeping Angel, 1859.

It’s late, and you’re still awake. Allow us to help with Sleep Aid, a series devoted to curing insomnia with the dullest, most soporific texts available in the public domain. Tonight’s prescription: a chapter from Experiments on the Spoilage of Tomato Ketchup, a 1909 book by A. W. Bitting. 

SPOILAGE OF KETCHUP AFTER OPENING.

The question of how long the ketchup should keep after opening the container in order to satisfy the ordinary requirements of consumption was also studied. A local restaurant, serving about two hundred meals and using from one-half to a gallon of ketchup daily, was supplied with the same kind of ketchup used in the experiments, as were also some families. Instructions were given to use the ketchup as they would ordinarily, with the result that none reported any loss from spoilage.

To determine how long the ketchup would keep after opening, 8 bottles from each of the first 9 experiments were kept in the kitchen at a temperature of about 72° F., 5 were kept in an incubator at a temperature of 95° F., 5 were kept in the laboratory at a temperature of about 67° F., and 4 were kept in an inclosed porch where the temperature ranged from 30° to 60° F. This made a total of 198 bottles. No precautions, other than those of ordinary cleanliness, were taken in opening the bottles, as it was desired to determine the keeping properties under conditions of general usage. The first set of bottles was opened November 5, immediately on being received at the laboratory, all of the ketchup having been kept at the factory until the experiment begun in September was completed. The bottles were covered loosely with a metal cap and observed daily, a record being kept of the date and character of spoilage.

The results showed that the differences in the time and temperature of processing had little, if any, effect in checking the spoilage; neither did the use of acetic acid or oil extracts. The most important precaution in checking the spoilage after opening seems to be to keep the ketchup cool. This is shown by the average number of days which elapsed before spoilage occurred in the sets kept under different temperature conditions. For those kept in the kitchen the average number of days was six, the minimum three, and the maximum eleven. Those in the incubator kept for an average of five days, with a minimum of two days, and a maximum of eight. Those in the laboratory had an average of eight days, the minimum being four days and the maximum twenty-two. Those kept in the porch lasted on an average twenty-seven days, a minimum of twelve days, and a maximum of fifty-eight.

These figures show the definite relation of temperature to spoilage under the conditions of ordinary use. In making the observations, the metal cap was removed each day, but no ketchup was poured off. The spoilage in all cases was due to mold, and usually this formed in the neck of the bottle where the ketchup had splashed, or at the junction of the ketchup with the bottle. The spoilage was recorded as soon as the slightest growth appeared. In actual use if the neck were wiped out when the ketchup had been used and a growth of mold removed on its first appearance with some of the proximate ketchup the time before spoilage occurred could be prolonged. In these experiments the attempt was made to determine how soon growth appeared under the various conditions of temperature named.

The unopened bottles of ketchup were kept in a basement room, the temperature of which is fairly constant, being about 70° F. This is approximately the condition in a grocery where the ketchup is kept on the shelves. Another set of samples from the run of September, 1907, was opened February 11, 1908, to determine if storing in a warm room before opening had any effect on the length of time preceding spoilage. Four bottles were taken from each of the first 9 experiments to make up each of three sets, one of which was kept in the kitchen, one in the incubator, and one in the porch, making a total of 108 bottles. The average number of days for those kept in the incubator was four, the minimum two, and the maximum six. The average number of days before spoilage in the kitchen was five, the minimum being three and the maximum nine. Those kept in the porch gave an average of twenty-three days, the minimum number being eighteen days and the maximum seventy-three days. Thus it is seen that the ketchup lasted nearly five times as long at a temperature of 30° to 60° F. as it did at 72°; and also that when ketchup is kept in a warm place before opening, spoilage occurs somewhat sooner, the average for the fresh samples opened under the same conditions being one day more with the incubator and kitchen samples and four days more with the porch samples.

A third set of bottles of the ketchup was opened on June 6, 1908, or two hundred and sixty-five days after manufacture. They had been kept in a basement at a temperature of about 70° F.

One set was placed in the incubator at a temperature of 95° F., one set in the kitchen at about 82° F., and one set in the refrigerator at 46° F. The weather was warm and the conditions favorable to the spoilage of fresh foods. The minimum time for spoilage in the incubator was two days, the maximum time four days, and the average time three and two-tenths days. The minimum time in the kitchen was two days, the maximum time six days, and the average time four and four-tenths days. The minimum time in the refrigerator was nine days, the maximum time nineteen days, and the average time thirteen and sixty-six one-hundredths days.

These data are grouped in the following table for easier comparison:

Time of spoilage of ketchup at different temperatures after opening.

SPOILAGE OF UNOPENED KETCHUP.

Another test was made to determine whether the ketchup would spoil when kept in a warm place, but not opened. Three bottles from each experimental batch were placed in the incubator November 7, 1907, and were kept there until December 23, 1907—forty-six days—and in that time there was no sign of spoilage. They were then opened and kept in the laboratory; the average number of days before spoilage occurred is indicated in the following table:

Average number of days before spoilage of ketchup after opening (kept 46 days at 95° before opening).

It will be observed that these samples spoiled in about the same length of time as the bottles opened in February and tested in the incubator, so that similar results were obtained by keeping unopened ketchup one and one-half months at 95° F. and keeping it five months at 70° F. From the results of the experiments it is evident that the ingredients of the ketchup in the proportions used are not antiseptic, and it is also apparent from the number of organisms found and the rapidity of their multiplication that ketchup is a good, nutritive medium. Yeasts and molds are the predominating organisms, and, as the ketchup is acid and also contains sugar, and these organisms are found on tomatoes in the field, their predominance in the ketchup is explained.

SPOILAGE OF MARKET BRANDS.

To determine the keeping properties of the ketchup on the market, various brands were obtained from the grocery stores. In the majority of cases nothing was known of the ingredients or methods of manufacture, except what appeared on the labels. No date of manufacture was given, and in some cases the dealers did not know the age of the product.

There were 104 bottles of ketchup opened to find out how long they would remain in good condition. These were kept in the laboratory, though the temperature was higher than that at which ketchup should be held. Of the 104 bottles there were 66 without preservative, according to the labels, 46 of which spoiled. Of the 20 which did not spoil, 2 formed crystals of benzoic acid on the covers of glass dishes during evaporation. Of the 39 which, according to the labels, contained sodium benzoate, 15 spoiled. The bottles of unspoiled ketchup after remaining in the laboratory for about a month were placed in the incubator at 95° F. for three weeks, and were then taken out, and have been left in the laboratory since. The metal cap had been taken off frequently for observation, and the ketchup exposed, but the treatment did not cause them to spoil.

The average number of days after which spoilage occurred for the 46 bottles without preservative was about fifteen, the minimum number being four days, the maximum number ninety-four days. The average number of days preceding spoilage in the case of 15 bottles with preservative was twenty-four days, the minimum number being three and the maximum sixty days. The majority of these had 0.1 per cent of sodium benzoate present; the others had a smaller amount, according to the manufacturer’s label. These data are not at all conclusive and further work on material of known history will be necessary.

STERILITY OF KETCHUP.

To determine the sterility of ketchup, cultures were made from 77 of the bottles. The method used was to wipe the bottles and cork stoppers with a damp towel and then remove the cork. The cork puller which was used grasps the neck of the bottle in such a way as to cover the opening and remove the cork without the inrush of air that occurs when the ordinary corkscrew is used. A flame was then passed over the mouth of the bottle, after which the upper layer of ketchup was poured out, so as to discard any material which might have been contaminated in handling. Tomato gelatin was used as a medium and cultures were made in petri dishes.

There were 17 plates on which no organisms developed, indicating that the ketchup was sterile. Of the 60 plates having organisms, 54 had molds, 22 of these having molds alone; 21 plates had yeast-like organisms, 3 plates having these only; 29 plates had bacteria, 4 having bacteria alone. Sometimes a plate would have only one form of organism, but more often there was a mixture present. Of 15 plates having only one form of organism, 3 had yeast alone, 2 bacteria alone, and 10 had mold alone. Of the 77 bottles of ketchup from which the inoculations were made, 41 were without and 36 with preservative, and of the 17 sterile ketchups, 8 contained sodium benzoate and 9 were without preservative.

A considerable part of the experimental ketchup proved not to be sterile. The organisms present were of the class which require oxygen for their growth and therefore they had only been arrested in their activity. No growth could take place so long as the air was excluded and therefore no spoilage could occur. When the cork was drawn, the organisms could grow and cause spoilage, and this is a much more potent factor than the entrance of germs from without. Bottling and sealing the ketchup quickly while hot so completely excludes the air that only a few colonies of yeast or mold may be found on subsequent microscopical examination. Filling at a low temperature and corking while cool allows sufficient air to remain incorporated in the ketchup and neck of the bottle to permit a considerable growth of the organisms and a product derived from good stock may thus acquire the appearance of ketchup derived from partially decayed material. A ketchup in which bubbles of air are incorporated in filling may show a growth of mold at each bubble throughout the mass. The foregoing statements apply to ketchup containing sodium benzoate as well as to the non-preservative goods of the character used in these experiments.

Still awake? Read more of our Sleep Aids.